作　　者： ; ; ; ; ;

机构地区： 中国科学院

出　　处： 《燃料化学学报》 2012年第3期309-314,共6页

摘　　要： 在小型流化床气化装置上进行了氧气-水蒸气气化实验,考察了原料、当量比、水蒸气配比、温度、二次风和床料对气化特性的影响。结果表明,原料中C和H含量越高,气化气中H2和CO含量越高,焦油含量越低;当量比为0.27和水蒸气配比为0.6时,H2含量达到最大值;温度的升高可提高H2含量,在840℃以上,可提高CO含量;二次风从进料口偏上且二次风比率为15%通入,气体组分变化较明显,二次风通入点位置越高,焦油含量降低幅度越大;白云石和石灰石裂解焦油和提高H2含量的活性高于橄榄石,但同时明显提高了气体中的灰分含量。 The characteristics of biomass gasification with oxygen-steam mixtures in a fluidized bed are studied in this paper.The effects of feedstock,equivalence ratio（ER）,steam to biomass ratio（S/B）,gasification temperature,secondary oxygen supply and bed materials on gasification performance were investigated.The results showed that higher C and H content of feedstock was more favorable for higher H2 and CO content and lower tar content of fuel gas.The H2 content increased with gasification temperature and reached its maximum at ER=0.27 and S/B=0.6.Higher gasification temperature（840 ℃） also contributed to higher CO content.The introduction of secondary flow upper the feedstock inlet with a second flow ratio of 15% improved the gas quality significantly,and more tar was reduced as the secondary flow inlet move upward the gasifier.Dolomite and limestone performed better than olivine on cracking tar and increasing H2 content,but resulted in higher ash content.

关 键 词： 生物质 流化床 气化 氧气 水蒸气

领　　域： [动力工程及工程热物理]